Pilot-scale study and biochemical verification of salt-tolerant catalyst Fe-Bi@γ-Al2O3 for catalytic ozonation of high-salinity wastewater

In this study, Fe-Bi@ γ-Al2O3 was used as a catalyst to construct a heterogeneous catalytic ozonation system for the treatment of high-salinity organic wastewater and its biochemical verification was studied. The optimum operating conditions and degradation mechanism of Fe-Bi@ γ-Al2O3 catalytic ozonation of high salinity wastewater were systematically investigated. The biodegradability of wastewater before and after treatment was also studied. Under the optimum operating conditions of ozone dosage of 160 mg/L, catalyst filling rate of 15%, ratio of height to diameter of 15, hydraulic retention time of 210 min and recycle ratio of 500%, the removal rate of COD is 45.13%. The mechanical strength of Fe-Bi@ γ-Al2O3 catalyst is almost unchanged after being reused for 20 times. The results of Ultraviolet and visible spectrophotometry (UV-Vis), 3D (Three-Dimensional)-fluorescence and Gas Chromatography-Mass Spectrometer (GC-MS)showed that humus, fulvic acid and undissolved microbial organic matter were degraded. In the biochemical verification experiment, after the high salinity wastewater was used to impact the bio-reactor, the mixed liquor suspended solids (MLSS) was basically stable at 9597 mg/L, 8856 mg/L, 9414 mg/L and 8741 mg/L, and the mixed liquor volatile suspended solids (MLVSS) was basically stable at 7042 mg/L, 6940 mg/L, 6949 mg/L and 6519 mg/L. The dissolved oxygen (DO) in the four reactors were 2.9 mg/L, 3.48 mg/L, 3.6 mg/L and 2.92 mg/L respectively, and the sludge Volume Index (SVI30) were 93 mL/g, 98 mL/g, 93 mL/g and 91 mL/g respectively. After two cycles (20d) of 30% high salinity wastewater, the chemical oxygen demand (COD) removal rates of the four reactors were 78%, 84%, 86% and 91%, respectively. When the reaction time is 40 min, the BOD5/COD (B/C) value of the high-salinity wastewater reaches 0.91, and the biodegradability of the wastewater is improved significantly. Scanning electron microscope (SEM) showed that the granular sludge in the reactor had compact structure and smooth surface, and there were a lot of fungi and filamentous microorganisms on the sludge surface.in that condition of salinity stress, the microbial community in the activate sludge changed to a great extent, and Proteobacteria and Bacteroidetes became the main phylum. The Fe-Bi@ γγ-Al2O3 catalyst has good catalytic performance and can be used for deep treatment of high-salt organic wastewater.