Recycling of Coal Fly Ash and Paper Waste to Improve Low Productive Red Soil in Okinawa, Japan

Abstract Coal fly ash (CFA) and paper waste (PW) related environmental problems and its recycling techniques have been a major challenge to society. Therefore, it is of crucial importance to develop new recycling methods for CFA and PW. This work proposes a potential new way of developing synthetic aggregates (SA) using CFA, PW, starch waste and ammonium sulfate (AS) as a granular nitrogen fertilizer medium, and their utilization as a soil amendment to improve crop production in the low productive acidic red soil of Okinawa, Japan. Three types of SA with three different nitrogen (N) percentages were produced and used to amend acidic red soil in a pot experiment for the cultivation of Komatsuna, which is also called as Japanese mustard spinach ( Brassica rapa var. pervidis ). SA had a low bulk density (0.58–0.62 g/cm 3 ), high water holding capacity (0.60–0.64 kg/kg), high saturated hydraulic conductivity (2.34·10 –2 cm/s), high mean weight diameter (MWD) (4.32–4.48 mm), alkaline pH (8.58–8.61), high electrical conductivity (EC) (82.18–84.35 mS/m) and high carbon (C) content (68.71–70.07 g/kg) in comparison with the acidic red soil. The trace element concentrations of the developed SA were below the maximum pollutant concentration of individual metals for land application of sewage sludge given by the US Environmental Protection Agency. Scanning electron microscopic (SEM) studies showed the higher structural surface area of SA, where round shaped CFA particles were embedded into the fibrous PW matrix. Incorporation of SA into the acidic red soil not only enhanced soil fertility but also improved the physical and chemical properties of the soil compared to soil without SA addition. SA addition to the acidic red soil significantly increased the growth and yield parameters of Komatsuna compared to soil without SA addition.