Alkali Lignin-Based Hydrogel: Synthesis, Characterization, and Impact on Soil Water Retention From Near Saturation to Dryness

Highlights A lignin-based hydrogel was synthesized and shown to possess a swelling ratio of 2013%. The hydrogel contained important hydrophilic hydroxyl groups and macropores for water retention. The hydrogel improved soil water retention in silt loam soil at high matric potentials and in the dry soil range. Increasing hydrogel concentration increased water retention in a loamy fine sand soil at high and low matric potentials. Abstract. Superabsorbent polymers (hydrogels) have been proposed as soil amendments to increase the amount of plant-available water in the soil. Synthetic hydrogels have been widely investigated for use in agriculture. Due to increasing environmental concerns related to synthetic hydrogels, naturally sourced hydrogels are of interest because of their potential for increased biodegradability and biocompatibility. A lignin-based hydrogel was synthesized for this study, and its swelling properties and water absorption capacity were determined. The hydrogel was characterized using scanning electron microscopy (SEM), Fourier transform infrared (FTIR) spectroscopy, and gas pycnometry. A hanging water column, pressure plate apparatus, and dew point potentiometer were used to measure the soil water retention curve from saturation to oven-dryness for silt loam and loamy fine sand soils after amendment with the lignin-based hydrogel. Results showed a maximum swelling ratio in deionized water of 2013% of the hydrogel’s original mass, 1092% in tap water, and 825% in a 0.9% NaCl solution. The FTIR spectra of the hydrogel showed the presence of O-H bonds from the lignin structure, which renders the hydrogel reactive to a crosslinker and forms insoluble bonds, thereby allowing the hydrogel to swell when exposed to water. SEM images of the lignin hydrogels indicate large macropores, which allowed for water absorption. Applying hydrogels significantly increased the soil's water-holding capacity at 0.3% (w/w) treatment. Hydrogel treatment significantly increased water retention at saturation or near saturation by 0.12 cm3 cm-3 and at field capacity by 0.08 cm3 cm-3 for silt loam soil at 1% (w/w) treatment compared to the control treatment with no added lignin hydrogel. Hydrogel application increased water retention over the range of the soil water retention curve from -3 to -15,000 cm for the loamy fine sand soil at 1% (w/w) treatment. However, the application of lignin-based hydrogel did not affect plant available water capacity (PAWC) in either soil tested. These results serve as preliminary evidence upon which further lignin-based hydrogel amendment studies could be built by testing higher concentrations of hydrogel in the soil. Keywords: Lignin, Soil water retention curve, Super absorbent polymers, Swelling capacity, Water retention.